澳门金莎娱乐网站

咨询热线:15703121115
主营产品: 电动葫芦,CD1钢丝绳电动葫芦,MD1钢丝绳电动葫芦,行车钢丝绳电动葫芦等各种型号起重设备。

24小时全国服务热线

0312-8496919

如果您有任何疑问或是问题,请随时与咱们联系

查看联系方式>>
金莎娱乐官方网站资讯 当前位置:金莎娱乐官方网站 > 资讯资讯 > 金莎娱乐官方网站资讯 >

CD1/MD1电动葫芦限位器安装调整

时间:2019-06-12 16:30????点击量:

断火限位器可有效的防止吊钩超出上升限位位置,从而避免冲顶、钢丝绳被拉断等故障,提升设备的安全性。限位器装置由连杆、定位卡子、导绳器、限位器(限位开关)组成,如果安装错误就不能发挥断火限位器的安全保护功能,澳门金莎娱乐网站整理了CD1/MD1电动葫芦限位器安装调整,或电询15833324666(加微信)。

1、

The fire-break limiter can effectively prevent the lifting hook from exceeding the lifting limit position, so as to avoid the failure of roof punch, wire rope being pulled and improve the safety of the equipment. The limit device is composed of connecting rod, positioning clip, guide rope device and limit device (limit switch). If the installation is wrong, the safety protection function of the limit device can not be played.

2、

松开撞块上的螺钉,撞块分置于导绳器卡板两侧,卡板能自如的推动撞块移动。启动电机开始起升,卡板推动上限撞块移动,升至吊钩滑轮外壳上沿距卷筒外壳下沿150mm~50mm时,停止上升,点动下降按钮,导绳器向回移动10mm左右时,停机,移动上限撞块靠近卡板,旋紧螺钉即可。

3、

Loosen the screw on the bump block, and the bump block is placed on both sides of the guide rope device card, which can freely push the bump block to move. When the upper edge of the hook pulley housing is 150mm ~ 50mm away from the lower edge of the drum housing, stop the rise and inching the down button. When the rope guide device moves back 10mm or so, stop the machine.

3、

下限位置的调整同上,只是方向相反,但必须保证吊钩处于低位置时,卷筒上留有3圈以上钢丝绳。调整完后,可空载试吊数次,验证上、下限位是否符合要求。

4、

The lower limit is adjusted in the same way as above, but in the opposite direction. However, when the hook is in the lowest position, there should be more than 3 laps of wire rope left on the reel. After the adjustment, the load can be tested several times to verify whether the upper and lower limits meet the requirements.

5、

断火限位器是行程开关的一种,断火就是切断电源,行程开关只是控制接触器的线圈,如果接触器本身出了问题,行程开关就起不到保护作用了。断火限位器是机械式保护,CD1/MD1电动葫芦限位器安装调整,接线正确的话,可以起到保护。限位器是限制钢丝绳只能在一定范围内提升或下降的一个保险机构,在钢丝绳导程器接触到断火限位器时,电动葫芦会自动停止。

6、

The circuit breaker is a type of travel switch, which means cutting off the power supply. The circuit breaker only controls the coil of the contactor. Disconnection limit device is mechanical protection, CD1/MD1 electric hoist limit device installation adjustment, wiring correctly, can play a protection. The limiter is an insurance mechanism that limits the hoisting or lowering of the wire rope within a certain range. When the wire rope guide device contacts the limiter, the electric hoist will automatically stop.

【返回列表页】
地址:河北省保定市清苑区东闾工业区澳门金莎娱乐网站  电话:郝经理(同微信):157-0312-1233??张经理(同微信):157-0312-1115??
传真:0312-5954166    ICP备案编号:冀ICP备17022359号-1????主营产品:电动葫芦,手拉葫芦,手扳葫芦,升降平台,电动吊篮,镀锌吊篮,简易龙门架等
网站地图
澳门金莎娱乐网站
XML 地图 | Sitemap 地图
Baidu
sogou